贝朗斯品牌叉车蓄电池贝朗斯,火炬

广州贝朗斯动力电源有限公司*经销火炬蓄电池，淄博火炬牌叉车电瓶，这种作用于电动叉车上的牵引蓄电池具备超长的设计寿命，可持续工作5小时以上，适合大型电瓶叉车使用，火炬牌蓄电池作为中船重工旗下企业，正极板的活性物质是多孔结构的，就与电解液——硫酸的接触面积来说，多孔结构是平面的数十倍。如果α氧化铅参与放电以后，重新充电以后只能够生成β氧化铅，这样就失去了支撑，

不仅仅会产生正极板活性物质脱落，而且脱落的活性物质还会堵塞正极板的微孔，导致正极板参与反应的真实面积下降，形成蓄电池容量的下降。后备电源的蓄电池使用年限要求比较严格，对蓄电池的容量要求比较宽，

因此后备电源使用的蓄电池α氧化铅和β氧化铅比例比深循环的动力型电池大一些。为了减少α氧化铅参与放电，一般控制放电深度仅仅为40%。随着蓄电池的使用时间的增加，叉车蓄电池主要为企业场内电瓶 叉车更换使用，针对那么多国内外品牌，如何正确的选择一组适合自己使用的电池组呢？

小编简单说下几点：首先需要根据自己的工作频率、起叉载重量、车辆铁箱 尺寸、车辆额定的电瓶重量来给予定位，比如一组杭州叉车电瓶，杭叉在市面上原配的多数为迅启、GS、火炬等品牌，首先我们可以考虑车辆原装的电池 品牌，或者根据自己的本身的使用年限来定，一般铁箱尺寸是固定的，

但是很多时候，铁箱的空隙还存在很大的空间，可以增加容量至20%不等，如果起叉的是大 件笨重的货物，需要消耗的电流比较大，标准配置已经满足不了使用所需。

叉车蓄电池的 输出电流决定它的使用时间，目前国产的电池循环寿命在800-1000次不等，进口或外资品牌可达1500次以上，但叉车电瓶价格比对翻了一翻，

不是常规 企业所能承受。我们建议使用软连接的，便捷自己在后期单体的更换与维护，针对外地发货的客户，不具备焊接的技术，*好购买软连接。

蓄电池的容量下降，新电池放电40%的电量，对于旧电池来说必然超过40%的，所以旧电池就相当于放电深度深，电池的正极板软化也会被加速。所以，电池的容量寿命曲线的后期下降速率远远高于中期。电池容量越小，放电深度越深，α氧化铅损失也越多，

正极板软化也越严重，导致蓄电池容量下降越快，形成了恶性循环。叉车电池虽然说是深循环放电电池，但若过去亏电，极板硫化会加快的，蓄电池组效率低是因为经常大电流放电引起的，本身叉车限制1.5吨的，长期叉货超过1.5吨或者接近1.5吨，放电深度对蓄电池使用寿命的影响也非常大，

火炬蓄电池放电深度越深，其循环使用次数就越少，尽管小电流放电能提高蓄电池的效率，但是当用极小电流长时间放电时，将导致蓄电池实际放出容量超过其额定容量，从而造成蓄电池严重的深度放电，当蓄电池放电深度为极限时，又要避免长时间，

轻载放电造成蓄电池深度放电，更要避免蓄电池短路放电，否则，会严重损坏蓄电池的再充电能力和储电能力，缩短使用寿命；一组叉车蓄电池按照1500次循环寿命计算，如果长期深度大电流放电，寿命至少缩短一半。 火炬蓄电池作为牵引电池领航品牌，

在国内外配套大量防爆叉车、电动叉车、观光车使用，一组电池价格并不便宜，如果在我们使用过程中，不注意保养，至使蓄电池亏电，那么，将大大增加了企业运营费用，火炬电池亏电电池放置3-7天，将有可能永久损坏，

因此，蓄电池使用过后请尽快充电。对于长期不使用的德国阳光蓄电池，应每隔15天左右对电池充电一次，以补偿蓄电池存放时的自放电电量损失，广州贝朗斯*火炬蓄电池销售、服务，可提供国产、进口全系列电动叉车配套。淄博火炬能源有限责任公司（原淄博蓄电池厂）创建于1944年1月，

是中国船舶重工集团公司的全资子公司。是我国*早研制和生产铅酸蓄电池的生产商之一，是山东省高新技术企业。

公司主要从事牵引用、固定用、电动车用铅酸蓄电池及锂离子动力电池的开发设计与生产，现具有年生产500万kVAh各类铅酸蓄电池的能力。Guangzhou Bei Langsi power supply Co. company specializes in distribution of Zibo torch torch battery, battery forklift, traction battery in electric forklift on this effect have long life design, sustainable work more than 5 hours, suitable for large battery forklift, torch battery enterprises as CSIC's, positive plate active material is porous the structure, and the electrolyte sulfate contact area, porous structure is dozens of times of the plane. If alpha lead oxide participates in discharge after recharging after only able to generate beta PbO, this will lose support,
Not only will the positive plate active material fall off, but also the active material will plug the pores of the positive electrode plate, leading to the positive plate to participate in the reaction of the real area of decline, the formation of battery capacity decline. Backup power supply battery life requirements are more stringent, the battery capacity requirements are relatively wide,
Therefore the battery backup power supply using the alpha lead oxide and lead oxide beta ratio deep circulation power type battery large. In order to reduce the discharge of lead oxide in alpha, the general control of the depth of discharge is only 40%. With the increase of battery time, replace the use of forklift battery enterprises are the main venue for the forklift, so many brands at home and abroad, how to choose a suitable set of batteries for their own use?
Small simple said a few points: first need to give their location according to the working frequency, fork load, vehicle iron box size, vehicle rated battery weight, such as a group of Hangzhou Hangcha forklift battery, the majority in the market for the original Xunqi, GS, torch and other brands, we can consider the original vehicle battery brand, or according to their own life to set general iron box size is fixed,
But most of the time, the gap in the iron box there is a large space, can increase the capacity to 20% range, if the fork is large bulky goods, need to consume relatively large current, the standard has been unable to meet the required.
Forklift battery output current determines its use time, the current domestic battery life cycle in 800-1000 times, imported or foreign brands up to more than 1500 times, but the forklift battery price than doubled,
Is not a conventional enterprise can withstand. We recommend the use of soft connection, convenient for their own replacement and maintenance of the latter monomer, for the delivery of customers in the field, do not have the welding technology, it is best to buy a soft connection.
Battery capacity decreased, the new battery discharge 40% of the electricity, for the old battery is bound to more than 40%, so the old battery is equivalent to the discharge depth is deep, the battery's positive plate will be accelerated softening. Therefore, the capacity of the battery life curve decline rate is much higher than the latter. The battery capacity is small, the discharge depth is deeper, more alpha lead oxide loss,
The softening of the positive plate is also more serious, which leads to the decline of the battery capacity. Although that is the deep cycle battery forklift battery discharge, but if the past loss of electricity, will speed up the plate curing, the battery efficiency is low because often cause a large current discharge limit of 1.5 tons of forklift itself, more than 1.5 tons of goods, long-term fork or close to 1.5 tons, the depth of discharge effect on the service life of the accumulator is also very big,
The battery discharge depth, the cycle number is less, despite the small current discharge can improve battery efficiency, but when the minimum current long time discharge, the battery will cause the actual discharging capacity exceeds its rated capacity, resulting in serious deep discharge battery, when the battery discharge depth limit, and to avoid long time,
Light load discharge caused by the battery depth of discharge, but also to avoid the battery short circuit discharge, otherwise, recharge capacity and storage capacity, serious damage to the battery, shorten the service life; a group of forklift battery is calculated according to 1500 cycles of life, if the long-term depth of large current discharge, shorten the life of at least half. Torch battery as traction battery pilot brand,
At home and abroad a large number of supporting explosion-proof forklifts, electric forklifts, sightseeing car using a battery, the price is not cheap, if we use in the process, do not pay attention to maintenance, to make the battery, then, will greatly increase the enterprise operating costs, the torch battery power loss battery placed in 3-7 days, will be permanently damaged,
Therefore, please charge the battery as soon as possible. For a long time does not use the German sunshine battery should be every 15 days on a single battery charge, battery storage to compensate the self discharge loss of power, Guangzhou Bei Langsi professional sales and service torch battery, can provide a full range of domestic and imported electric forklifts. Zibo torch Energy Co., Ltd. (formerly Zibo storage battery factory) was founded in January 1944,
Is a wholly owned subsidiary of China Shipbuilding Industry Corp. It is one of the earliest producers of lead-acid batteries in China, and it is a high-tech enterprise in Shandong province.
The company is mainly engaged in the use of electric vehicles, and fixed with the development of design and production of lead-acid battery and lithium ion battery with annual production capacity of traction, the 5 million kVAh all kinds of lead-acid battery.